If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Fix for 2003-2004 ION non start problem
Hi all,
Recently a friend of mine had some trouble with her 2003 ion. When she would try to start it in the morning, especially if it was cold outside, the engine would do nothing (or maybe just one turn, then nothing), and a warning light would flash. It was a security light with a lock. Wait a while, then try again, and it would usually start. The problem is this: There is an ignition switch that tells the computer to unlock the security system and allow the car to be started when the key is turned. That switch has grease that is too thick, and it will stick. If you turn the key and the switch doesn't send a signal to the computer, the car thinks you are stealing it, and it locks down for 8-10 minutes. The solution is this: Go to a Saturn dealership and ask for the NEW ignitions switch. When I went in the guy said "we sell these things all the time". The part is about $50. It takes an hour to install. It's pretty easy, except that there are a few hex / star screws that are difficult to reach because of the angle. Remove the cover from around the steering column, and you will see the switch. Remove the switch, replace with the new one, replace the covers. Now you have to re-program the security system. It's easy. Turn the key to START, then release (leave in the ON position). The system will lock down. Wait 15 minutes. Turn the key forward to START, then release again (leave in ON pos). System will lock down 2nd time. Repeat a third time. After the third time, the car will start. You might have to turn it back to the OFF position after the 3rd time, I'm not sure. Good luck. |
Ads |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Intermittent no start when hot 2004 Mustang | Jessica V. | Ford Mustang | 1 | January 27th 07 12:21 AM |
2004 CRV no start | rudyc | Honda | 2 | October 19th 06 05:31 AM |
Remote Start on 2002-2004 A6s ? | eBob.com | Audi | 9 | February 6th 05 03:09 PM |
2004 330 xi wouldn't start in the cold | Nick Pemberton | BMW | 7 | December 21st 04 11:04 PM |
1998 SL1 electrical problem- won't start, will start, replaced fuel pump relay | D | Saturn | 6 | August 23rd 04 09:17 PM |