If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
91 Jetta Clutch Cable
Ok, Here's the update. New clutch plate, pressure plate, flywheel, release
bearing plate and circlip. Just replaced release rod ans another release bearing. Still grinds and will not go into gear. Auto adjust clutch cable SEEMS to work. I need help. -- Rex Merriweather www.stunttrumpet.com |
Ads |
#2
|
|||
|
|||
Only 2 things I can think of: clutch cable is stretched out but you
can not tell visually. Internal problem with trans. Step 1 replace clutch cable and go from there |
#3
|
|||
|
|||
It might also be a cracked release arm/lever that is in the transmission.
It is the lever the cable is attached to, pivots, and pushes the release bearing. I have seen these crack and cause problems like what you describe. pop that cover off and have someone step on the clutch pedal while you examine the arm/lever's action. I am currently handling an 86 trans that likes to eat release bearings and pushrods. :-( I might change out the little housing with the release arm/lever in it. It was fine for about 2 years, but now after a new clutch it is at it again. What fun! lol "Rex Merriweather" > wrote in message ... > Ok, Here's the update. New clutch plate, pressure plate, flywheel, release > bearing plate and circlip. Just replaced release rod ans another release > bearing. Still grinds and will not go into gear. Auto adjust clutch cable > SEEMS to work. I need help. > > -- > Rex Merriweather > www.stunttrumpet.com > > > |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
91 Jetta self adjusting clutch cable. | Rex Merriweather | VW water cooled | 4 | February 19th 05 04:39 PM |
95 Neon Clutch cable issues | mike | Dodge | 0 | January 4th 05 08:38 PM |
Clutch Cable | David Holland | VW air cooled | 5 | December 29th 04 12:03 AM |
94 Jetta clutch and transmission | Victor LeeOwn | VW water cooled | 6 | October 20th 04 11:56 AM |