If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Location of Fan Blower Resistor
Help. I can't find the fan blower resistor on my 99 Mercury
Mountaineer with climate control. I bought the replacement part and expected to find it in the usual location(s)--in the ductwork ds of the fan under the hood. Well there is a lot if aluminized insulation on the box but no wires going in that I can see. So I took the glove compartment out thinking it might be in the passenger compartment--no joy. Anybody know the location of this part? Thanks, Jerry |
Ads |
#2
|
|||
|
|||
Location of Fan Blower Resistor
ItNo Twilight wrote:
> Help. I can't find the fan blower resistor on my 99 Mercury > Mountaineer with climate control. I bought the replacement part and > expected to find it in the usual location(s)--in the ductwork ds of the > fan under the hood. Well there is a lot if aluminized insulation on > the box but no wires going in that I can see. So I took the glove > compartment out thinking it might be in the passenger compartment--no > joy. Anybody know the location of this part? > > Thanks, > Jerry > It is in the blower housing but the auto climate control does not use a resistor. It uses a motor controller which is significantly more expensive. If you're looking under the hood at the blower motor the controller is at about 5 o'clock. There's a black wireplug that goes into it. |
#3
|
|||
|
|||
Location of Fan Blower Resistor
On the 1998 Mountaineer the Blower Motor Switch Resistor, if that's what
you're referring to: The heater blower motor switch resistor has the following features: 1. - The assembly is located on the evaporator housing in the engine compartment. 2. - Three resistance elements are mounted on the resistor board to provide four blower motor speeds. 3. - Depending on the heater blower motor switch position, series resistance is added or bypassed in the blower motor circuit to decrease or increase blower motor speed. 4. - An overheating protective device (thermal limiter) will open the resistor coil circuit when the temperature reaches 121ºC (250ºF) interrupting the blower motor operation in all speeds except HI. 5. - The thermal limiter cannot be reset and is not serviceable. Good luck, Steven No Twilight wrote: > Help. I can't find the fan blower resistor on my 99 Mercury > Mountaineer with climate control. I bought the replacement part and > expected to find it in the usual location(s)--in the ductwork ds of the > fan under the hood. Well there is a lot if aluminized insulation on > the box but no wires going in that I can see. So I took the glove > compartment out thinking it might be in the passenger compartment--no > joy. Anybody know the location of this part? > > Thanks, > Jerry > |
#4
|
|||
|
|||
Location of Fan Blower Resistor
Thanks Steve,
That was the problem. The dealer sold me a resistor and I needed the controller. They should have the controller for me today and I can see where it goes. Thanks, Jerry Steve Sigman wrote: > ItNo Twilight wrote: > > Help. I can't find the fan blower resistor on my 99 Mercury > > Mountaineer with climate control. I bought the replacement part and > > expected to find it in the usual location(s)--in the ductwork ds of the > > fan under the hood. Well there is a lot if aluminized insulation on > > the box but no wires going in that I can see. So I took the glove > > compartment out thinking it might be in the passenger compartment--no > > joy. Anybody know the location of this part? > > > > Thanks, > > Jerry > > > > It is in the blower housing but the auto climate control does not use a > resistor. It uses a motor controller which is significantly more > expensive. If you're looking under the hood at the blower motor the > controller is at about 5 o'clock. There's a black wireplug that goes > into it. |
#5
|
|||
|
|||
Location of Fan Blower Resistor
OK. Followup. It's a little difficult to get to. The screws that
hold it in are sheetmetal screws and take an 8mm socket. I removed what I think is the cruise control actuator (one 10mm head screw) and used a 1/4" drive ratchet to remove the outboard one--slow and tedious. I used a replacable tipped screwdriver adapted to the 8mm socket with about 10" of extension to reach the inboard one pretty easily. You'll need a flashlight or shoplight even in good lighting. Fan works fine now. (symptom was no controlled speeds, only high and off) --Jer No Twilight wrote: > Thanks Steve, > That was the problem. The dealer sold me a resistor and I needed the > controller. They should have the controller for me today and I can see > where it goes. Thanks, Jerry > > Steve Sigman wrote: > > ItNo Twilight wrote: > > > Help. I can't find the fan blower resistor on my 99 Mercury > > > Mountaineer with climate control. I bought the replacement part and > > > expected to find it in the usual location(s)--in the ductwork ds of the > > > fan under the hood. Well there is a lot if aluminized insulation on > > > the box but no wires going in that I can see. So I took the glove > > > compartment out thinking it might be in the passenger compartment--no > > > joy. Anybody know the location of this part? > > > > > > Thanks, > > > Jerry > > > > > > > It is in the blower housing but the auto climate control does not use a > > resistor. It uses a motor controller which is significantly more > > expensive. If you're looking under the hood at the blower motor the > > controller is at about 5 o'clock. There's a black wireplug that goes > > into it. |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
05 Stratus blower resistor location | « Paul »[_1_] | Chrysler | 2 | July 1st 06 09:23 PM |
1996 Dodge Grand Caravan LE AC/Heater Blower, Relay and Resistor Block Problems 101 | HeadlessHorseman | Dodge | 2 | January 12th 06 11:12 PM |
HONDA PILOT BLOWER MOTOR RESISTOR LOCATION | ckeagy | Honda | 4 | November 3rd 05 02:12 AM |
1996 Dodge Grand Caravan LE AC/Heater Blower, Relay and Resistor Block Problems 101 | HeadlessHorseman | Dodge | 0 | January 5th 05 02:49 PM |