If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Dodge Caravan A/C Evacuation Problem
I have a 1998 Dodge Grand Caravan. Bought it new. It's been great.
Last fall I had a problem as I was heading into Florida. The A/C was on. At some point the CD started skipping and finally quit. We pulled the CD out and noticed a bunch of very cold water on it. Obviously the tube that is supposed to evacuate the moisture from the AC unit was plugged and backing up under the dash. I stopped at a dealer. They determined there was a blockage in the evacuation hose. The AC worked perfectly for the rest of the trip (about a week). Living in Indiana, we seldom use the AC in the winter months, so it sat unused until about May first. At that point it did the same thing. Again I took it to the dealer. They found a blockage in the hose. Again they charged me about $40. Yesterday it did it again. I fail to believe there keeps getting something stuck in the hose that quickly. I've had it for 6 years and it never did it. Now it's done it three times in a row? Does anyone have any ideas, other than just giving them another $40 to tell me there is debris in that hose? Jim |
Ads |
#2
|
|||
|
|||
|
#3
|
|||
|
|||
|
#4
|
|||
|
|||
On Mon, 24 May 2004 17:42:12 -0400, gumbo5_99 wrote:
> Living in Indiana, we seldom use the AC in the winter months, so it sat > unused until about May first. At that point it did the same thing. Again > I took it to the dealer. They found a blockage in the hose. Again they > charged me about $40. Yesterday it did it again. I fail to believe there > keeps getting something stuck in the hose that quickly. I've had it for > 6 years and it never did it. Now it's done it three times in a row? That is such a ripoff. All you have to do is either lift the front end and get under it or reach down from above (first idea probably easier). Then, you'll find an L-shaped little rubber tube, that might just look like it's crimped shut on the end, like the end of a popsicle (you know, the ones you buy in packs of 50 and 100 that you have to freeze first, little plastic tubes, you know the kind). That's the drain tube. Like Gene said, they clog easily. I had my passenger floorboard sopping wet before I realized I even had a problem (A/C hadn't worked in 5 years). All you need is either to prop it open with a harder plastic tube, snip off the very end of it, or cram a screwdriver into it (carefully) every oil change or so to ensure it stays clear. I think the reason it didn't do it for six years was that it took that long to build up the grime, and now, they're not getting all the grime out or something. Still seems a bit frequent, but check it yourself if you don't believe them. For $40 you can probably get a decent set of drive-on ramps or a jack and jackstands. Then, you're almost equipped to do your own oil changes, your own suspension work, etc etc etc. Just need tools. HIH CJ |
#5
|
|||
|
|||
On Mon, 24 May 2004 17:42:12 -0400, gumbo5_99 wrote:
> Living in Indiana, we seldom use the AC in the winter months, so it sat > unused until about May first. At that point it did the same thing. Again > I took it to the dealer. They found a blockage in the hose. Again they > charged me about $40. Yesterday it did it again. I fail to believe there > keeps getting something stuck in the hose that quickly. I've had it for > 6 years and it never did it. Now it's done it three times in a row? That is such a ripoff. All you have to do is either lift the front end and get under it or reach down from above (first idea probably easier). Then, you'll find an L-shaped little rubber tube, that might just look like it's crimped shut on the end, like the end of a popsicle (you know, the ones you buy in packs of 50 and 100 that you have to freeze first, little plastic tubes, you know the kind). That's the drain tube. Like Gene said, they clog easily. I had my passenger floorboard sopping wet before I realized I even had a problem (A/C hadn't worked in 5 years). All you need is either to prop it open with a harder plastic tube, snip off the very end of it, or cram a screwdriver into it (carefully) every oil change or so to ensure it stays clear. I think the reason it didn't do it for six years was that it took that long to build up the grime, and now, they're not getting all the grime out or something. Still seems a bit frequent, but check it yourself if you don't believe them. For $40 you can probably get a decent set of drive-on ramps or a jack and jackstands. Then, you're almost equipped to do your own oil changes, your own suspension work, etc etc etc. Just need tools. HIH CJ |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
New *FREE* Corvette Discussion Forum | JLA ENTERPRISES TECHNOLOGIES INTEGRATION | Corvette | 12 | November 30th 04 06:36 PM |
2000 Grand Caravan Radio Problem | Jen | Dodge | 4 | May 18th 04 12:42 AM |
Dodge Caravan - replacing radio/tape player | Chas Stokes | Dodge | 1 | May 8th 04 09:41 AM |
Dodge Grand Caravan 2005 | FaXiA | Dodge | 6 | May 1st 04 05:13 AM |