If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
How to Remove and clean Throttle body 2006 Dodge Caravan 3.3L
Removed throttle body for cleaning.............74973 KM
I first of all removed air filter cover..........disconnected plug attached to rubber accordion hose...........to disconnect plug, slide red lock slider on top of disconnect plug backwards and pull plug out...............PS when you reconnect make sure you lock red slider. Unscrew clamp that holds accordion air cleaner hose to throttle body and remove hose. 1 ) Remove two throttle cables......easy.......... push throttle up against spring tension then remove cables. Two ( 2 ) plugs are on metal throttle body............I removed screws that held throttle body to engine................handling throttle body carefully because plugs and wires are still attached,..........remove top plug by first sliding the red slider lock backwards, which is on the UNDERNEATH side of this plug...........pull plug off. Now the lower grey plug attached to the throttle body was a whole different story........it took me almost an hour trying to figure out how you separate the plug.......... it was agonizing, seemed no logical way...........finally I got a very small screwdriver about three inches long, with a very thin shaft 5/64 inch and slid it into the opening on top of the pull out half of the plug..........the screwdriver released the lock tab this plug has......pulled plug out.................throttle body now detached. Back of throttle body plate is smeared with black carbon, which must be removed. Cleaner used..............Kleen---Flo..........Air Intake Kleen...........from NAPA ..........get 2 cans..................this cleaner and two clean cloths. Perhaps you may also want to use a tooth brush I did not...............I did use my air compressor. Spend time giving a good clean to the throttle body. |
Ads |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
2006 Caravan Body Kits? | HotRod | Chrysler | 6 | August 22nd 06 04:09 PM |
2006 Caravan Body Kits? | HotRod | Dodge | 6 | August 22nd 06 04:09 PM |
How to remove wiper arms on 2001 Dodge Caravan | [email protected] | Dodge | 2 | March 5th 06 11:02 AM |
Shudders at stop light: Clean throttle body? | Richard | Saturn | 2 | December 18th 04 10:58 PM |
Shudders at stop light: Clean throttle body? | Richard | Technology | 2 | December 18th 04 10:58 PM |