If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
95 Accord AC problems - NEED ADVICE!
Hi all,
I have a 95 Accord EX that is blowing hot air from the AC. I asked the mechanic to take a look at it when I had it in the shop getting a new master cylinder. He said he found the evaparator core was rusted out and would not hold freon at all - this would need to be completely replaced. The part from Honda ran ~$500. Does this sound about right? Would this type of thing be too much for a DIY'r? What is the best manual to help me though it? TIA |
Ads |
#2
|
|||
|
|||
Casey Chester wrote: > > Hi all, > > I have a 95 Accord EX that is blowing hot air from the AC. I asked the > mechanic to take a look at it when I had it in the shop getting a new master > cylinder. He said he found the evaparator core was rusted out and would not > hold freon at all - this would need to be completely replaced. The part from > Honda ran ~$500. Does this sound about right? Would this type of thing be > too much for a DIY'r? What is the best manual to help me though it? TIA If all the refrigerant (R134a, NOT freon) has leaked out, you don't have to worry about the recovery part of the process. Installing a new evaporator can be done by a home mechanic. You should also replace the dryer (or receiver/dryer, depending on the type of system). You absolutely need to evacuate the system with a good vacuum pump before charging it with R134a. Unless you have / have access to a good vacuum pump, you should leave this job to the pro's. If you decide to do this yourself, get the factory service manual from http://www.helminc.com. Pricey, but worth every penny. -- ================================================== ===== A very modest collection of Honda tech info can be found at: http://www.geocities.com/ng_randolph |
#3
|
|||
|
|||
I would get a second opinion. I have worked on loads of auto AC units and
have NEVER seen an evaporator ever even begin to rust out. I have however, seen loads of bad "O" rings at connection points. I suggest you put some R-134A in the system and spray all connections with soapy water. Remember you have gas and oil circulating in the system so don't forget to add the correct Honda refrigeration oil to your system after the leak is repaired but before you evacuate the system and add freon. When freon leaks out, so can the oil. You also might be able to find the leak by finding an oily connection on one of your AC lines. Good luck! |
#4
|
|||
|
|||
On Wed, 22 Jun 2005 18:15:07 -0400, "duckbill"
> wrote: >I would get a second opinion. I have worked on loads of auto AC units and >have NEVER seen an evaporator ever even begin to rust out. I have >however, seen loads of bad "O" rings at connection points. I suggest you >put some R-134A in the system and spray all connections with soapy water. >Remember you have gas and oil circulating in the system so don't forget to >add the correct Honda refrigeration oil to your system after the leak is >repaired but before you evacuate the system and add freon. When freon >leaks out, so can the oil. You also might be able to find the leak by >finding an oily connection on one of your AC lines. Good luck! they don't rust, they are aluminum! they do corrode though. and this year accord is famous for it. It's not an o-ring. replace the expansion valve and drier while you're at it. Chip |
#5
|
|||
|
|||
First, I'm sure we were all using rust as a layman's term for corrosion.
Second, I would still get a second opinion and do a leak check myself. Third, I would do a search on Evaporator Leaks in this very fine forum. You will find the following quote: "the pressure switch and the evaporator are known problems" I'm not an Accord expert but I have a 95 Civic EX with 187K and a 98 Civic EX and both have had AC problems that are now fixed. The 98's problem turned out to be a bad O ring. Good luck. |
#6
|
|||
|
|||
On Thu, 23 Jun 2005 19:41:22 -0400, "duckbill"
> wrote: >First, I'm sure we were all using rust as a layman's term for corrosion. >Second, I would still get a second opinion and do a leak check myself. >Third, I would do a search on Evaporator Leaks in this very fine forum. >You will find the following quote: "the pressure switch and the evaporator >are known problems" I'm not an Accord expert but I have a 95 Civic EX with >187K and a 98 Civic EX and both have had AC problems that are now fixed. >The 98's problem turned out to be a bad O ring. Good luck. > > the civics didn't have the evap problems, the accords are always leaking. as for the pressure switch, use a sniffer on a brand new car, unplug the pressure switch and test, it will leak, that's why that connector has an o-ring in it, it's one of the only ones that does. i replace evaps on a weekly basis on this body style though. Chip |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Accord EX V6 2005 Transmission Problems? | DaveR | Honda | 3 | May 31st 05 09:10 PM |
2005 Accord LX, fluttering sound while idle (and various other problems) | elmo | Honda | 1 | April 23rd 05 05:01 PM |
Honda OEM Parts Catalogs for Sale | Joe | Honda | 0 | February 12th 05 01:43 PM |
2000 Accord EX V6 Startup problems | Jack | Honda | 4 | January 15th 05 05:53 AM |
Panel Lights/Pwr Door lock problems - 1994 Honda Accord LX Coupe | LuckMeister | Honda | 0 | October 24th 04 04:39 PM |