If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Diesel Fuel Tank Corrosion Issue
Dear All,
I have following this grp a lot quite lately and found it justifying to post my query here.. I am associated with a leading OEM manufacturer of commercial vehicles in India. We are grappling with a rather familiar problem right now - FUEL TANK CORROSION.. To have a forward on this problem. Mild steel uncoated tanks corroding at the weld lines thereby causing leakage issues especially at the bottom. Also the tank construction incorporates baffles which makes reaching inside quite tough. It is my thinking that the fuel tank corrosion happens especially when the humidity inside the closed tank is high which causes water-vapor to condense and react with steel, thus giving rise to excessive rusting. The water vapor usually seeps into the fuel tanks along improper weld lines, which serve the purpose of defective zones. Also the presence of sulpher in diesel, especially in the presence of water at the bottom of the tank, aggravates this situation causing the weld lines to preferentially corrode in the absence of oxygen thereby causing the leakage that we are experiencing. Also the rust particles as a result clog the diesel fuel filter and the pump thereof. POSSIBLE REMEDY : I was thinking of flushing the tank with phosphoric acid as a pre-treatment measure to Ferric Phosphates and then give a epoxy based primer coat in the inside as well as outside. Please adivice me on the same ... Regards, Barath |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Starting Problems | McNick | Jeep | 12 | October 1st 05 03:58 AM |
Why you should never buy a car without a tachometer | Ted B. | Driving | 112 | September 19th 05 04:09 AM |
HELP!!! Gona have me one 300C Touring Disel... HELP!!! | 2BIG4U | Chrysler | 7 | June 24th 05 03:35 AM |
warman i am surprised you mix oil | [email protected] | Ford Mustang | 5 | May 8th 05 04:04 AM |
DaimlerChrysler Commits Over $70 Million to Fuel Cell | Shrike | Dodge | 0 | March 30th 05 09:03 PM |