If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Bad rectifier or component in alternator drains battery.
A 1988 Ford Escort with 1.9 L inline 4 has a 6 amp drain out of the
battery when the ignition is off. The initial symptom was a weak battery unable to start car. Car started when jumped, but battery didn't appear to charge. In circuit voltage test showed 6V, and battery assumed bad. Battery taken to PEP Boys (Local parts dealer) who tested battery and said it was fine. Of interest was that out of circuit the battery voltage was 10V, which was a hint of heavy current draw. Back to the car went the battery, and 6 amps were seen coming out of the battery with ignition off and all lights off in car, including the under hood courtesy light (one of the nicest touches of the Escort). Disconnecting alternator at both connectors ended the 6 amp draw, with car pulling only 20 mA after alternator disconnected. A new alternator was installed and the 6 amp draw is gone. The counter guy at Pep Boys confirmed that alternator failure manifest as heavy current flow when the engine is off is a common failure mode for an alternator. Apparently the rectifier diodes in the alternator short out and allow reverse current to flow and drain the battery. Modern cars have the voltage regulator integral with the alternator. It used to be you could buy service kits with new diodes and replace the failed parts. Given that I have had 18 years of service and over 160000 miles it looks like I got good service out of the part. I'm posting this so that others who try to fix their cars with a VOM and Google can find a hint. |
Ads |
#2
|
|||
|
|||
Bad rectifier or component in alternator drains battery.
Good info :1: -- AudioGuy93DelSol ------------------------------------------------------------------------ AudioGuy93DelSol's Profile: http://www.automotiveforums.com/vbul...?userid=174364 View this thread: http://www.automotiveforums.com/vbul...d.php?t=611687 http://www.automotiveforums.com |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
dual battery | ihcnut via CarKB.com | 4x4 | 19 | July 31st 06 01:23 PM |
Help. replaced dead battery, now engine starts but won't run. | tonyw | VW water cooled | 18 | July 31st 06 07:39 AM |
Battery shorted, jump started fine, now it's dead but shows fully charged? | Flippy Smith | Technology | 5 | July 12th 06 07:00 PM |
2000 Honda Accord EX - Cold start problems (parasitic battery draw) | [email protected] | Honda | 3 | December 11th 05 02:33 AM |
battery question | Jim Beaver | General | 14 | November 6th 04 10:54 PM |