If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Type I Clutch Cable
I have a 1967 Type I Beetle with a stock diaphragm clutch. The clutch
cable breaks every couple of years. It always breaks at one of the ends where the cable is crimped into the fitting. It never breaks anywhere in between. I always grease the cable upon installation. Is this common to break this often? Are there any heavy duty clutch cables available? Any suggestions to help the situation? Note: Remove the "-nospam" from e-mail address to reply. |
Ads |
#2
|
|||
|
|||
Type I Clutch Cable
Doug wrote:
> I have a 1967 Type I Beetle with a stock diaphragm clutch. The clutch > cable breaks every couple of years. It always breaks at one of the ends > where the cable is crimped into the fitting. It never breaks anywhere in > between. I always grease the cable upon installation. Is this common to > break this often? Are there any heavy duty clutch cables available? Any > suggestions to help the situation? > > Note: Remove the "-nospam" from e-mail address to reply. Good cables should last many, many years. I imagine there is a lot of crap on nthe market now. See if John can help you: http://www.aircooled.net/ Jim |
#3
|
|||
|
|||
Type I Clutch Cable
Speedy Jim wrote:
> Doug wrote: > >> I have a 1967 Type I Beetle with a stock diaphragm clutch. The clutch >> cable breaks every couple of years. It always breaks at one of the >> ends where the cable is crimped into the fitting. It never breaks >> anywhere in between. I always grease the cable upon installation. Is >> this common to break this often? Are there any heavy duty clutch >> cables available? Any suggestions to help the situation? >> >> Note: Remove the "-nospam" from e-mail address to reply. > > Good cables should last many, many years. > I imagine there is a lot of crap on nthe market now. > > See if John can help you: > http://www.aircooled.net/ > > > Jim I sent him the same question but have yet to hear back. |
#4
|
|||
|
|||
Type I Clutch Cable
"Doug" > wrote in message . .. >> >> See if John can help you: >> http://www.aircooled.net/ >> >> >> Jim > > I sent him the same question but have yet to hear back. Doug, John C is very quick to respond...if you don't hear from him in a day or so, it is possible that your email was sent to his spam folder.....just a heads up type thing, because John is very quick.... |
#5
|
|||
|
|||
Type I Clutch Cable
Do you notice any jerking as you move the clutch pedal?
Or does the clutch pedal operate very smoothly? I am thinking that something is binding. If the body is rusty then it could even be the body falling down and the top of the clutch operating lever is hitting it. It could also be the Bowden tube not correctly bent with washers/spacers. good luck! later, dave (One out of many daves) "Doug" > wrote in message ... >I have a 1967 Type I Beetle with a stock diaphragm clutch. The clutch cable >breaks every couple of years. It always breaks at one of the ends where the >cable is crimped into the fitting. It never breaks anywhere in between. I >always grease the cable upon installation. Is this common to break this >often? Are there any heavy duty clutch cables available? Any suggestions to >help the situation? > > Note: Remove the "-nospam" from e-mail address to reply. |
#6
|
|||
|
|||
Type I Clutch Cable
The clutch operates very smoothly and the bowden tube has a couple of
washers in it to increase the sag to about 1". I don't remember where I bought the last cable, but I am beginning to think there are some bad ones out there. I take it that aircooled.net sells cable as good as they get, is that correct? Any suggestions as to where to buy and not buy? dave AKA vwdoc1 wrote: > Do you notice any jerking as you move the clutch pedal? > Or does the clutch pedal operate very smoothly? > I am thinking that something is binding. If the body is rusty then it could > even be the body falling down and the top of the clutch operating lever is > hitting it. > > It could also be the Bowden tube not correctly bent with washers/spacers. > > good luck! > later, > dave > (One out of many daves) > > "Doug" > wrote in message > ... >> I have a 1967 Type I Beetle with a stock diaphragm clutch. The clutch cable >> breaks every couple of years. It always breaks at one of the ends where the >> cable is crimped into the fitting. It never breaks anywhere in between. I >> always grease the cable upon installation. Is this common to break this >> often? Are there any heavy duty clutch cables available? Any suggestions to >> help the situation? >> >> Note: Remove the "-nospam" from e-mail address to reply. > > |
#7
|
|||
|
|||
Type I Clutch Cable
Doug
I'm not sure there are any very special cables out there, I've been getting the same ones for many years and haven't had breaking problems. I would also shop around, you can always get the same quality at a lower price then at aircooled.net. I just visited Sundance Bug and Buggie last weekend in Tampa, it was walking in to a candy store. Mario Vintage Werks resto |
#8
|
|||
|
|||
Type I Clutch Cable
"Joey Tribiani" > wrote:
>Doug, John C is very quick to respond...if you don't hear from him in a day >or so, it is possible that your email was sent to his spam folder.....just >a heads up type thing, because John is very quick.... He is. And I appreciate his terse responses. But ya know, one day John C. will take a vacation and someone will cry a river. |
#9
|
|||
|
|||
Type I Clutch Cable
"2" > wrote in message ... > "Joey Tribiani" > wrote: > >>Doug, John C is very quick to respond...if you don't hear from him in a >>day or so, it is possible that your email was sent to his spam >>folder.....just a heads up type thing, because John is very quick.... > > He is. And I appreciate his terse responses. > > But ya know, one day John C. will take a vacation and someone will cry a > river. > > it has happened before..LOL....but the crying is usually due to emails not being received by John...which reminds me....i emailed John a part question about two months ago....he probably didn't get it...i may resend...<G> |
#10
|
|||
|
|||
Type I Clutch Cable
I have had my 67 for 9 years now, and have been fortunate have never
had a clutch cable break. Also have never had an accelerator cable or clutch pedal return spring break as I have on other VWs in the past. |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
96 Jetta Clutch Cable | Warren Abrey | VW water cooled | 8 | July 20th 05 10:03 PM |
95 Jeep Wrangler Shifting problems | [email protected] | Jeep | 12 | January 21st 05 06:56 PM |
95 Neon Clutch, cable snap? | Michael | Chrysler | 6 | January 3rd 05 06:08 PM |
Clutch question | XS11E | Ford Mustang | 8 | December 9th 04 06:12 PM |
Clutch died on '96 Golf 1.8 | Wakeley Purple | VW water cooled | 12 | October 21st 04 10:31 AM |