If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Engine having trouble keeping steady coolant temp
I have a 1993 SC-2 with 105K on it. Up until now, the temperature gauge has
always been quite steady in all types of weather and driving conditions, typically staying just below the mid-point, or just above it. I just noticed that the engine runs hot when I have the AC on (it goes over 3/4 of the way, but not quite to the red danger zone) and, without the AC, I've noticed a more than usual fluctuation in the engine temp. Going up hills will send the temp close to 3/4, and going down hills can send the temp to below 1/4. Even during steady driving, the temperature needle seems to wander around much more than I remember. Is this a case of a broken thermostat, or perhaps a faulty coolant temp sensor? If so, how hard are they to replace? |
Ads |
#2
|
|||
|
|||
"MPost" > wrote in message ... > I have a 1993 SC-2 with 105K on it. Up until now, ... > Is this a case of a broken thermostat, or perhaps a faulty coolant temp > sensor? If so, how hard are they to replace? Possibly. Could also be signs of a defective cooling fan, defective AC fan, a clogged radiator, a bad water pump, or a leaking/blown head gasket too. What preventive maintenance has been done on the cooling system in this vehicle over the years? If it has been more than two years since the last complete radiator flush and fill, I'd start there with a good radiator flush. Bob |
#3
|
|||
|
|||
I had a complete radiator flush at 80K, which was probably just under a
couple of years ago. One other thought: about a week ago, I got a low coolant light...I immediately pulled over and filled up with 100% antifreeze (about a quart) as I didn't have water to mix in with it. I've put about 250 miles on the car after that with no problems before this problem showed up. Could that be related? "Bob Shuman" > wrote in message ... > > "MPost" > wrote in message > ... >> I have a 1993 SC-2 with 105K on it. Up until now, ... > >> Is this a case of a broken thermostat, or perhaps a faulty coolant temp >> sensor? If so, how hard are they to replace? > > Possibly. Could also be signs of a defective cooling fan, defective AC > fan, > a clogged radiator, a bad water pump, or a leaking/blown head gasket too. > What preventive maintenance has been done on the cooling system in this > vehicle over the years? If it has been more than two years since the last > complete radiator flush and fill, I'd start there with a good radiator > flush. > > Bob > > > |
#4
|
|||
|
|||
when the coolant was changed did you change the thermostat also??
|
#5
|
|||
|
|||
No. Just did a radiator flush and coolant change.
> wrote in message ups.com... > when the coolant was changed did you change the thermostat also?? > |
#6
|
|||
|
|||
Assuming your fans are running correctly and there is no debris blocking the
front of the radiator, I'd suggest you flush again now since it is nearly 2 years and due for this anyway. If possible, I also suggest use of a good radiator flush and follow all bottle directions. Make sure you get as much antifreeze out as possible before using it and then make sure you drain it a few times using fresh rinse water afterward, then fill to 50/50 minimum and 65/35 maximum (depends on where you live and coolest temp seen during winter). I also recommend the garden hose flush systems available from Prestone, etc. They do a nice job and you will see a lot of rust come out when you reverse flush the system. Also change the thermostat and make sure you remove and completely clean the overflow reservoir. I use my [pressure washer to get all that gunk off the plastic container. When refilling, use the Saturn approved correct fluid available from the dealer since Saturn is funny about what they recommend and most off the shelf coolants contain phosphates which is a no no for Saturn. Also, make sure you get the pellets from the dealer and crush and put them into the radiator as well since this will help prevent a head gasket problem. If this still doesn't correct the problem, I'd replace the Coolant Temperature Sender next. Good luck and post what you do and if it helps for others benefit. Bob "MPost" > wrote in message ... > No. Just did a radiator flush and coolant change. > > > wrote in message > ups.com... > > when the coolant was changed did you change the thermostat also?? > > > > |
#7
|
|||
|
|||
Check to see that the plastic air dam is still under the car and hasn't been
torn off. It has a measurable effect on cooling. Lane [ lane (at) evilplastic.com ] --- Visit my Saturn Car Audio and Performance Page at http://www.evilplastic.com "MPost" > wrote in message ... > I have a 1993 SC-2 with 105K on it. Up until now, the temperature gauge has > always been quite steady in all types of weather and driving conditions, > typically staying just below the mid-point, or just above it. I just noticed > that the engine runs hot when I have the AC on (it goes over 3/4 of the way, > but not quite to the red danger zone) and, without the AC, I've noticed a > more than usual fluctuation in the engine temp. Going up hills will send the > temp close to 3/4, and going down hills can send the temp to below 1/4. Even > during steady driving, the temperature needle seems to wander around much > more than I remember. > > Is this a case of a broken thermostat, or perhaps a faulty coolant temp > sensor? If so, how hard are they to replace? > > |
#8
|
|||
|
|||
On Wed, 3 Aug 2005 22:41:01 -0500, in rec.autos.makers.saturn "Lane"
> wrote: > Check to see that the plastic air dam is still under the car and hasn't been > torn off. It has a measurable effect on cooling. I lost both the air dam and the splash panel in a flood a couple of years ago. There's been no effect on cooling as far as I can see. Of course, I'm in San Antonio... |
#9
|
|||
|
|||
In article >,
William Hughes > wrote: > On Wed, 3 Aug 2005 22:41:01 -0500, in rec.autos.makers.saturn "Lane" > > wrote: > > > Check to see that the plastic air dam is still under the car and hasn't been > > torn off. It has a measurable effect on cooling. > > I lost both the air dam and the splash panel in a flood a couple of years ago. > There's been no effect on cooling as far as I can see. Of course, I'm in San > Antonio... Maybe the cooling fan has packed it in. I recently lost the fan on my 91 SL2 and had cooling problems at lights and in slow traffic. |
#10
|
|||
|
|||
I can hear my cooling fan kick in when I pull up to my garage at night, just
before I shut the engine off. I initially thought it was the cooling fan, but that wouldn't explain why the car actually runs cool at times. "ORVAL FAIRAIRN" > wrote in message news > In article >, > William Hughes > wrote: > >> On Wed, 3 Aug 2005 22:41:01 -0500, in rec.autos.makers.saturn "Lane" >> > wrote: >> >> > Check to see that the plastic air dam is still under the car and hasn't >> > been >> > torn off. It has a measurable effect on cooling. >> >> I lost both the air dam and the splash panel in a flood a couple of years >> ago. >> There's been no effect on cooling as far as I can see. Of course, I'm in >> San >> Antonio... > > Maybe the cooling fan has packed it in. I recently lost the fan on my 91 > SL2 and had cooling problems at lights and in slow traffic. |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
rec.autos.makers.chrysler FAQ, Part 1/6 | Dr. David Zatz | Chrysler | 5 | May 24th 05 05:27 AM |
rec.autos.makers.chrysler FAQ, Part 1/6 | Dr. David Zatz | Chrysler | 5 | May 8th 05 05:29 AM |
rec.autos.makers.chrysler FAQ, Part 1/6 | Dr. David Zatz | Chrysler | 2 | April 22nd 05 05:32 AM |
rec.autos.makers.chrysler FAQ, Part 1/6 | Dr. David Zatz | Chrysler | 7 | February 1st 05 01:43 PM |
rec.autos.makers.chrysler FAQ, Part 1/6 | Dr. David Zatz | Chrysler | 10 | January 2nd 05 05:15 AM |