If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Smog check HC question
Hello.
I replaced cat converter 2 yrs ago to bring down HC in wife's 81 VW Scirocco. Now the car's failing due to high HC again, with only about 2800 miles since last test! Results: 15mph, 1807rpm HC max: 162 - HC meas: 149 CO max: 1.09 - CO meas: 0.27 NO max: 1227 - NO meas: 983 25mph, 1938rpm HC max: 132 - HC meas: 172 FAIL CO max: 1.09 - CO meas: 0.27 NO max: 1227 - NO meas: 791 The car is driven every few days for short trips except was driven about 15-20 miles on the freeway before the test. Also, tester ran it for 2 minutes at 2K or so before starting the test. It has over 250K miles and does pass some oil - about 1qt every 200 miles or so I think. It doesn't smoke in normal driving though, and near-new plugs look toasty-good. Question: I put a bottle of Techron in the tank. Is there a chance running that out on the freeway would clean up the test results, or is a new cat the answer? (Can a cat go bad in 2800 miles?!) Also: what effect does Techron have on a smog test? Does it all have to be run out and refueled before testing? thx, nf |
Ads |
#2
|
|||
|
|||
Smog check HC question
nutso fasst wrote:
> Hello. > > I replaced cat converter 2 yrs ago to bring down HC in wife's 81 VW > Scirocco. Now the car's failing due to high HC again, with only about 2800 > miles since last test! Results: > > 15mph, 1807rpm > HC max: 162 - HC meas: 149 > CO max: 1.09 - CO meas: 0.27 > NO max: 1227 - NO meas: 983 > > 25mph, 1938rpm > HC max: 132 - HC meas: 172 FAIL > CO max: 1.09 - CO meas: 0.27 > NO max: 1227 - NO meas: 791 > > The car is driven every few days for short trips except was driven about > 15-20 miles on the freeway before the test. Also, tester ran it for 2 > minutes at 2K or so before starting the test. It has over 250K miles and > does pass some oil - about 1qt every 200 miles or so I think. It doesn't > smoke in normal driving though, and near-new plugs look toasty-good. > > Question: I put a bottle of Techron in the tank. Is there a chance running > that out on the freeway would clean up the test results, or is a new cat the > answer? (Can a cat go bad in 2800 miles?!) > > Also: what effect does Techron have on a smog test? Does it all have to be > run out and refueled before testing? > > thx, > nf Have you replaced the O2 sensor? Or had someone tweak the mixture adjustment on the fuel distributor? (techron is a good idea tho, dirty injectors are another possibility) A VW shouldn't NEED a catcon to pass emissions, I know lots of people with gutted and/or known failed cats (myself included) who have passed smog tests with flying colors. If you are anywhere near DC I advise you to just give the car to me, because early body Sciroccos are utterly worthless and certainly not any good for monster 1.8 turbo swaps Seriously, though, a quart in 200 miles is not good, engine might just be getting tired if a real tune-up doesn't get it to pass. Your cat might well be dead already if all that oil is being burned and not leaking out. Good news is that vee-dub 4-cyls are near unbreakable so it should be ready for another good 250K after a rebuild. nate -- replace "fly" with "com" to reply. http://home.comcast.net/~njnagel |
#3
|
|||
|
|||
Smog check HC question
"Nate Nagel" > wrote in message ... > Have you replaced the O2 sensor? Or had someone tweak the mixture > adjustment on the fuel distributor? (techron is a good idea tho, dirty > injectors are another possibility) A VW shouldn't NEED a catcon to pass > emissions, I know lots of people with gutted and/or known failed cats > (myself included) who have passed smog tests with flying colors. The car invariably passed smog checks w/o cat replacement until 239K miles ('98). Then the HC numbers were way out, and a new cat brought them way down. The car passed in 2000 and just barely in 2002. In 2004 needed another cat to pass. So we get one cat going 238K, next 10K, and next...2.8K? I don't think it's been using THAT much more oil. It's been tuned, CO adjusted and O2 sensor replaced a while ago - symptoms don't indicate O2 sensor, do they? Any idea what effect Techron will have on the test if tested with it still in the tank? > If you are anywhere near DC I advise you to just give the car to me, > because early body Sciroccos are utterly worthless and certainly not any > good for monster 1.8 turbo swaps That sounds perfectly unreasonable. Hmm, maybe I should be asking what's involved in a 1.8 turbo swap! Anyway, I'm on the best coast. > Seriously, though, a quart in 200 miles is not good, engine might just > be getting tired if a real tune-up doesn't get it to pass. Your cat > might well be dead already if all that oil is being burned and not > leaking out. Good news is that vee-dub 4-cyls are near unbreakable so > it should be ready for another good 250K after a rebuild. Maybe so, but also needs a fender, weatherstrip, upholstery, headliner, paint, dashboard, wiring, CV joints...and who knows what else. It sure has been the best car I've ever had though. Only 2 sets of tires, 2 brake jobs, 2 timing belts, and IIRC only one clutch in 252K miles. In its youth it got 36 mpg hwy, 29 city. nf |
#4
|
|||
|
|||
Smog check HC question
nutso fasst wrote: > "Nate Nagel" > wrote in message > ... > > Have you replaced the O2 sensor? Or had someone tweak the mixture > > adjustment on the fuel distributor? (techron is a good idea tho, dirty > > injectors are another possibility) A VW shouldn't NEED a catcon to pass > > emissions, I know lots of people with gutted and/or known failed cats > > (myself included) who have passed smog tests with flying colors. > > The car invariably passed smog checks w/o cat replacement until 239K miles > ('98). Then the HC numbers were way out, and a new cat brought them way > down. The car passed in 2000 and just barely in 2002. In 2004 needed another > cat to pass. So we get one cat going 238K, next 10K, and next...2.8K? I > don't think it's been using THAT much more oil. It's been tuned, CO adjusted > and O2 sensor replaced a while ago - symptoms don't indicate O2 sensor, do > they? > > Any idea what effect Techron will have on the test if tested with it still > in the tank? > > > If you are anywhere near DC I advise you to just give the car to me, > > because early body Sciroccos are utterly worthless and certainly not any > > good for monster 1.8 turbo swaps > > That sounds perfectly unreasonable. Hmm, maybe I should be asking what's > involved in a 1.8 turbo swap! Anyway, I'm on the best coast. > > > Seriously, though, a quart in 200 miles is not good, engine might just > > be getting tired if a real tune-up doesn't get it to pass. Your cat > > might well be dead already if all that oil is being burned and not > > leaking out. Good news is that vee-dub 4-cyls are near unbreakable so > > it should be ready for another good 250K after a rebuild. > > Maybe so, but also needs a fender, weatherstrip, upholstery, headliner, > paint, dashboard, wiring, CV joints...and who knows what else. It sure has > been the best car I've ever had though. Only 2 sets of tires, 2 brake jobs, > 2 timing belts, and IIRC only one clutch in 252K miles. In its youth it got > 36 mpg hwy, 29 city. > > nf I just don't like your oil consumption... I would suggest just dropping in a junkyard engine (hell, I sold an '84 with similar mileage for $600 a while back that *didn't* burn oil) but I'm not 100% familiar with the earlier cars, I don't know what would and wouldn't bolt in without any mods at all. High oil consumption can cause failures of both the O2 sensor and the cat well before their time, and on a car with a cat you won't see any smoke until the cat is well and truly trashed. nate |
#5
|
|||
|
|||
Smog check HC question
"N8N" > wrote in message oups.com... > I just don't like your oil consumption... I would suggest just dropping > in a junkyard engine (hell, I sold an '84 with similar mileage for $600 > a while back that *didn't* burn oil) but I'm not 100% familiar with the > earlier cars, I don't know what would and wouldn't bolt in without any > mods at all. High oil consumption can cause failures of both the O2 > sensor and the cat well before their time, and on a car with a cat you > won't see any smoke until the cat is well and truly trashed. Yeah, the oil consumption seems pretty high. The amount is an estimate, don't really track exactly when I add because I'm not the driver. I'm thinking I'll give this tank of Techron a long run today and see how quickly oil level goes down. No $ to do major work right now but wife needs this car badly. Any idea how Techron-treated gas will affect smog check? Thanks for taking the time to reply. nf |
#6
|
|||
|
|||
Smog check HC question
nutso fasst wrote:
> Hello. > > I replaced cat converter 2 yrs ago to bring down HC in wife's 81 VW > Scirocco. Now the car's failing due to high HC again, with only about 2800 > miles since last test! Results: > > 15mph, 1807rpm > HC max: 162 - HC meas: 149 > CO max: 1.09 - CO meas: 0.27 > NO max: 1227 - NO meas: 983 > > 25mph, 1938rpm > HC max: 132 - HC meas: 172 FAIL > CO max: 1.09 - CO meas: 0.27 > NO max: 1227 - NO meas: 791 > > The car is driven every few days for short trips except was driven about > 15-20 miles on the freeway before the test. Also, tester ran it for 2 > minutes at 2K or so before starting the test. It has over 250K miles and > does pass some oil - about 1qt every 200 miles or so I think. It doesn't > smoke in normal driving though, and near-new plugs look toasty-good. > > Question: I put a bottle of Techron in the tank. Is there a chance running > that out on the freeway would clean up the test results, or is a new cat the > answer? (Can a cat go bad in 2800 miles?!) > > Also: what effect does Techron have on a smog test? Does it all have to be > run out and refueled before testing? > > thx, > nf > > > > If you really want to keep the car,and keep it cheap, put in some Restore(?), engine rebuild in a can, put a few hundred miles on it, put in a new cat & get tested again. If you pass(you should), go home, remove cat, replace with old one, & drive it until next test. Repeat process as needed. -- Steve Walker (remove wallet to reply) |
#7
|
|||
|
|||
Smog check HC question
"Steve Walker" > wrote in message news:1twCg.14176$rd1.9396@trnddc01... > If you really want to keep the car,and keep it cheap, put in some > Restore(?), engine rebuild in a can, put a few hundred miles on it, put > in a new cat & get tested again. If you pass(you should), go home, > remove cat, replace with old one, & drive it until next test. Repeat > process as needed. Brilliant! Thanks. nf |
#8
|
|||
|
|||
Smog check HC question
nutso fasst > wrote:
> Hello. > > I replaced cat converter 2 yrs ago to bring down HC in wife's 81 VW > Scirocco. Now the car's failing due to high HC again, with only about 2800 > miles since last test! Results: > > 15mph, 1807rpm > HC max: 162 - HC meas: 149 > CO max: 1.09 - CO meas: 0.27 > NO max: 1227 - NO meas: 983 > > 25mph, 1938rpm > HC max: 132 - HC meas: 172 FAIL > CO max: 1.09 - CO meas: 0.27 > NO max: 1227 - NO meas: 791 > > The car is driven every few days for short trips except was driven about > 15-20 miles on the freeway before the test. Also, tester ran it for 2 > minutes at 2K or so before starting the test. It has over 250K miles and > does pass some oil - about 1qt every 200 miles or so I think. It doesn't > smoke in normal driving though, and near-new plugs look toasty-good. > > Question: I put a bottle of Techron in the tank. Is there a chance running > that out on the freeway would clean up the test results, or is a new cat the > answer? (Can a cat go bad in 2800 miles?!) > > Also: what effect does Techron have on a smog test? Does it all have to be > run out and refueled before testing? The Techron is good, but you need more than that. With that level of oil consumption and all the short trips you have a lot of carbon build-up. Get a can of Berryman B12 Total Combustion Cleaner Kit. Get the engine well warmed up then follow the directions. Then go out and drive and FLOOR IT until smoke stops billowing out the tailpipe. Depending on how much buildup you have this will take a couple blocks to a couple of miles. Run the techron in the gas tank too. After both of these change the oil, it will be black. -- E Frank Ball |
#9
|
|||
|
|||
Smog check HC question
nutso fasst wrote: > I replaced cat converter 2 yrs ago to bring down HC in wife's 81 VW > Scirocco. Now the car's failing due to high HC again, with only about 2800 > miles since last test! Results: > > 15mph, 1807rpm > HC max: 162 - HC meas: 149 > CO max: 1.09 - CO meas: 0.27 > NO max: 1227 - NO meas: 983 > > 25mph, 1938rpm > HC max: 132 - HC meas: 172 FAIL > CO max: 1.09 - CO meas: 0.27 > NO max: 1227 - NO meas: 791 > > The car is driven every few days for short trips except was driven about > 15-20 miles on the freeway before the test. Also, tester ran it for 2 > minutes at 2K or so before starting the test. It has over 250K miles and > does pass some oil - about 1qt every 200 miles or so I think. It doesn't > smoke in normal driving though, and near-new plugs look toasty-good. I doubt the Techron helped with this. What may let you pass emissions are using the hottest spark plugs allowed and changing the oil to 20W-50. Were 1981 Sciroccos part of a recall for high hydrocarbons? VWs made until some time in the early 1980s had valve stem seals that would wear out and cause a quart of oil to be burned every 100-200 miles. VW initially said this was normal, but they were later forced by the EPA to fix this, and a recall was issued that included new valve seals, valve adjustment, and, for some model years, elimination of the EGR valve and replacement of it with just an ignition vacuum advance time delay. I think the recall was called MK or KQ. The valve seals on this engine can be replaced without removing the head if you pump air into the spark plug hole or stuff non-fraying rope through the hole and turn the engine by hand slightly to compress it. |
#10
|
|||
|
|||
Smog check HC question
> wrote in message ups.com... > I doubt the Techron helped with this. What may let you pass emissions > are using the hottest spark plugs allowed and changing the oil to > 20W-50. Exclusively Castrol 20W-50 since I bought the car w/10,000 miles on it. > Were 1981 Sciroccos part of a recall for high hydrocarbons? Interesting...would a recall fix still be available if I never received a notification? I seem to recall, though, problems with Rabbits made in USA, not Sciroccos made in Germany. Anyway, the car passed all checks until 1998 (239,000 miles), when it failed HC miserably and got its CAT replaced for the first time. And I know it wasn't using a lot of oil when I was driving the car a lot prior to 1994. Valve seal failure does seem a logical explanation for seeing smoke after the engine is started cold, and why it would use more oil per mile on short trips. > The valve seals > on this engine can be replaced without removing the head if you pump > air into the spark plug hole or stuff non-fraying rope through the hole > and turn the engine by hand slightly to compress it. Good tip. Thanks! nf |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
C5 - Check Engine Question | Mike | Corvette | 3 | November 9th 05 12:24 AM |
Check Engine - question | [email protected] | Technology | 14 | October 28th 05 05:16 AM |
SMOG Check - high HC & NO - please help | Brian | Technology | 0 | August 6th 05 11:45 PM |
1985 Plymouth Reliant 2.2L California Smog Check TEST ONLY | Donald Erickson | General | 1 | September 4th 04 03:08 AM |
AVOID SMOG CHECK at Ocean Ave 76 station in San Francisco, California, SMOG check in SF, CA | Me | General | 0 | May 18th 04 06:04 AM |