If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
91 Acura Integra - High NOx - Failed emissions test - NJ
My 91 acura Integra LS failed the emission test a second time for high
NOx. Could the gurus please provide some input on what I should be checking? Here are the details. Test 1: NOx - 1984 HC - 91 CO% - .34 CO2% - 14.3 O2% - .6 After this test, my mechanic replaced the Catalytic convertor. The second test results we Test 2: NOx - 1367 HC - 10 CO% - 0.00 CO2% - 13.2 O2% - .9 So, the NOx did drop but not enough to pass the test. (The pass level of NOx in NJ is 1088) Any recommendations on what could be the big culprit? Thanks in advance. |
Ads |
#3
|
|||
|
|||
91 Acura Integra - High NOx - Failed emissions test - NJ
TeGGeR® wrote:
> wrote in > oups.com: > >> My 91 acura Integra LS failed the emission test a second time for high >> NOx. Could the gurus please provide some input on what I should be >> checking? Here are the details. >> >> Test 1: >> NOx - 1984 >> HC - 91 >> CO% - .34 >> CO2% - 14.3 >> O2% - .6 >> >> After this test, my mechanic replaced the Catalytic convertor. The >> second test results we >> Test 2: >> NOx - 1367 >> HC - 10 >> CO% - 0.00 >> CO2% - 13.2 >> O2% - .9 >> >> So, the NOx did drop but not enough to pass the test. (The pass level >> of NOx in NJ is 1088) >> >> Any recommendations on what could be the big culprit? >> >> Thanks in advance. >> >> > > > > If you have an automatic, check the EGR system. indeed. the op needs to make sure the ignition is set correctly too. a lot of non-honda mechanics don't bother with the service connector when setting timing and it's frequently out. > > Check base ignition timing. With the Service Check Connector shorted, the > timing mark on the timing belt cover should be in the middle of the group > of three on the crank pulley. > > I'm wondering if the reduction side of your "new" cat is defective. Your > CO2 reading is WAY too low. It should be well over 15%. > > By the way, NJ is *extremely* generous with their limits. Where I live, > they're postively totalitarian about it: > http://www.tegger.com/hondafaq/misc/...emissions.html > |
#4
|
|||
|
|||
91 Acura Integra - High NOx - Failed emissions test - NJ
Thanks guys. Tegger, jim you were right on the mark. It was the base
ignition timing. I had that adjusted and the NOx dropped to 1013 and passed the test. jim beam wrote: > TeGGeR® wrote: > > wrote in > > oups.com: > > > >> My 91 acura Integra LS failed the emission test a second time for high > >> NOx. Could the gurus please provide some input on what I should be > >> checking? Here are the details. > >> > >> Test 1: > >> NOx - 1984 > >> HC - 91 > >> CO% - .34 > >> CO2% - 14.3 > >> O2% - .6 > >> > >> After this test, my mechanic replaced the Catalytic convertor. The > >> second test results we > >> Test 2: > >> NOx - 1367 > >> HC - 10 > >> CO% - 0.00 > >> CO2% - 13.2 > >> O2% - .9 > >> > >> So, the NOx did drop but not enough to pass the test. (The pass level > >> of NOx in NJ is 1088) > >> > >> Any recommendations on what could be the big culprit? > >> > >> Thanks in advance. > >> > >> > > > > > > > > If you have an automatic, check the EGR system. > > indeed. the op needs to make sure the ignition is set correctly too. a > lot of non-honda mechanics don't bother with the service connector when > setting timing and it's frequently out. > > > > > Check base ignition timing. With the Service Check Connector shorted, the > > timing mark on the timing belt cover should be in the middle of the group > > of three on the crank pulley. > > > > I'm wondering if the reduction side of your "new" cat is defective. Your > > CO2 reading is WAY too low. It should be well over 15%. > > > > By the way, NJ is *extremely* generous with their limits. Where I live, > > they're postively totalitarian about it: > > http://www.tegger.com/hondafaq/misc/...emissions.html > > |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Question about 94 Acura Integra shocks and springs | [email protected] | Honda | 0 | January 9th 06 02:35 PM |
1988 Olds 88 3800V6 keeps blowing cam sensors, high HC, CO emissions | Glen Cooper | Technology | 9 | January 5th 05 04:18 AM |
Drive Clean, old A2s, and NOx emissions | Garry Tarr | VW water cooled | 1 | November 9th 04 12:18 PM |
Integra Emissions Failure | Dkakd | Honda | 13 | November 8th 04 09:14 AM |
92 SL2 DOHC failed smog test - 15mph NOx | Bill Mudd | Saturn | 3 | June 21st 04 11:28 PM |