If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
overheating problem 96 accord
Hi, all.
1996 Accord EX-R Vtec 5-speed 320,000 kms I have a somewhat perplexing overheating problem. Starting last summer, I noticed the temp gauge would slowly rise at highway speeds with the A/C on and while I was pulling a heavy boat (it didn't overheat for 4 years previous with in this condition). I shrugged it off as being something I should expect to happen under those conditions. To make a long story short, as of now, on moderately warm days, the car will overheat with just me in it, no boat no A/C. The temp gauge climbs only slightly, but putting on A/C, climbing a hill or obviously, pulling the boat worsens it to the point where I need to throw the cabin heat on full to keep the needle from climbing. This is what I have done/noticed during the past year. The rad seems to be in fine condition ( I've had worse) and the coolant always looks as new. I took it into Honda and they diagnosed the sensor that turns on the fans (the same two fans that the A/C opereates but this switch turns them on when the car is running even if the A/C is off) as faulty. (I had already determined this as the first time I noticed a severe overheat condition was when I left the car running for 4 minutes to get a coffee. After returning, the needle was all the way in the red. If I hit the A/C button, the temp dropped rapidly when the fans kicked on.). Being a student, I couldn't afford the $50 for the sensor so what I did was short-circuit the switch, making both fans run full time. The condition persisted. I was convinced the entire time it was my [original] thermostat but Honda told me it was fine. I changed it anyway and Honda was right, as the problem is still there. Bottom line is, it's not the thermostat and the cooling fans run al the time and the car overheats. I have read on these N/Gs that there are often faulty temp sensors. I'm sure Honda checked this out. I also believe this to not be the problem as the symptoms seems to point to an actual high heat condition. So what are my next possibilities? The only two I can think of is restricted flow through the cooling system and/or a rad that needs replacing. Can someone recommend to me how to check for either? IS there such a thing as a cooling system flush that removes built up residue? Advice on changing a rad? Thanks a million in advance, MajBach |
Ads |
#2
|
|||
|
|||
"MajBach" > wrote in message .. .
> 1996 Accord EX-R Vtec 5-speed 320,000 kms > I have a somewhat perplexing overheating problem. Starting last summer, I > noticed the temp gauge would slowly rise at highway speeds with the A/C on > and while I was pulling a heavy boat (it didn't overheat for 4 years > previous with in this condition). I shrugged it off as being something I > should expect to happen under those conditions. To make a long story short, > as of now, on moderately warm days, the car will overheat with just me in > it, no boat no A/C. The temp gauge climbs only slightly, but putting on A/C, > climbing a hill or obviously, pulling the boat worsens it to the point where > I need to throw the cabin heat on full to keep the needle from climbing. > This is what I have done/noticed during the past year. The rad seems to be > in fine condition ( I've had worse) and the coolant always looks as new. I > took it into Honda and they diagnosed the sensor that turns on the fans (the > same two fans that the A/C opereates but this switch turns them on when the > car is running even if the A/C is off) as faulty. (I had already determined > this as the first time I noticed a severe overheat condition was when I left > the car running for 4 minutes to get a coffee. After returning, the needle > was all the way in the red. If I hit the A/C button, the temp dropped > rapidly when the fans kicked on.). Being a student, I couldn't afford the > $50 for the sensor so what I did was short-circuit the switch, making both > fans run full time. The condition persisted. > I was convinced the entire time it was my [original] thermostat but Honda > told me it was fine. I changed it anyway and Honda was right, as the problem > is still there. Bottom line is, it's not the thermostat and the cooling fans > run al the time and the car overheats. > I have read on these N/Gs that there are often faulty temp sensors. I'm sure > Honda checked this out. I also believe this to not be the problem as the > symptoms seems to point to an actual high heat condition. > So what are my next possibilities? The only two I can think of is restricted > flow through the cooling system and/or a rad that needs replacing. Can > someone recommend to me how to check for either? IS there such a thing as a > cooling system flush that removes built up residue? Advice on changing a > rad? You didn't mention if you bleed the cooling system after checking the switch and after replacing the thermostat. For some reason if you have trapped air in the heater core or elsewhere you may find that the water pump will cease to do it's job correctly. I've not seen the actual scientific proof of this but most often this can lead to an overheat. Bleed according to the service manual for your particular model, or bleed so that all air is out. Let us know how you bleed it, just to be sure. |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
honda accord engine problem | dexue | Honda | 6 | April 1st 05 06:16 PM |
93 Accord 2.2SE start problem | [email protected] | Honda | 13 | March 28th 05 01:01 AM |
2001 Accord EX seat problem | Enrique Gonzales | Honda | 1 | March 19th 05 05:01 PM |
96 Accord Cruise control problem | me | Honda | 4 | March 8th 05 10:11 PM |
HONDA ACCORD 92 (SEDAN) Ignition Problem | Zul | Honda | 2 | March 7th 05 02:10 PM |