My Van (1993 Astro engine code W 154,000 miles)
is failing California's smog requirement.

Tested the van on rollers under load and found this:

HC's at 15 MPH (1475 RPM):
164 PPM. Allowed: 88 PPM max.

It passes in CO% and it passes for NOx (PPM) with flying colors
and in the 25 MPH test it passes all three w/no problems...
It runs clean at idle, and it runs clean at 2500 RPM (no load)

The van has never failed smog before and otherwise runs perfectly. This
is the first time it's ever had to run on the rollers under load.

In an attempt to fix it I just replaced all the fuel injectors and the
fuel pressure regulator, pcv valve. It now runs a bit cleaner:

It now fails w/109 PPM HC (down from 164. It's allowed 88)

The van has had a fairly recent tune-up that included ign. wires,
plugs, rotor, fuel filter, cleaned the K&N filter etc. This was only
about 10,000 miles ago.

Compression is good, starts right up, no CES codes, runs with about the
same fuel economy as it ever has...

So basically it only belches out smog when I cruise around in a parking
lot. What the heck do I do now?

Thanks,

Rayvan