AutoBanter

AutoBanter (http://www.autobanter.com/index.php)
-   Jeep (http://www.autobanter.com/forumdisplay.php?f=14)
-   -   Instrument Panel (http://www.autobanter.com/showthread.php?t=25815)

twaldron March 2nd 05 07:32 PM

Loose connector behind the dash. It is a common prob. and there is a TSB
out on it.

Rick Farley wrote:

> I live in the Sierras and over the past winter I have had a problem with my
> instrument panel losing power when I have driven in the cold and snow and
> have had my heater on, not knowing if the heater is part of the problem. I
> have a 99 TJ Sahara and the first indication I get is that my airbag light
> comes on then I lose speedometer and tachometer, then finally the rest of
> the gauges. If I turn the vehicle off and restart it about 5 - 10 minutes
> later everything is fine.
>
> Any thoughts?
>
>


--
__________________________________________________ _________
tw

71 Bill Stroppe Baja Bronco
03 TJ Rubicon - Rubicon Express 4.5"
01 XJ Sport

There is a very fine line between "hobby" and "mental illness."
-- Dave Barry

Pronunciation: 'jEp
Function: noun
Date: 1940

Etymology: from g. p. (G= 'Government' P= '80 inch wheelbase')
A small general-purpose motor vehicle with 80-inch wheelbase,
1/4-ton capacity, and four-wheel drive used by the U.S. army in
World War II.

(Please remove the OBVIOUS to reply by email)
__________________________________________________ _________

Rick Farley March 2nd 05 07:40 PM

Instrument Panel
 
I live in the Sierras and over the past winter I have had a problem with my
instrument panel losing power when I have driven in the cold and snow and
have had my heater on, not knowing if the heater is part of the problem. I
have a 99 TJ Sahara and the first indication I get is that my airbag light
comes on then I lose speedometer and tachometer, then finally the rest of
the gauges. If I turn the vehicle off and restart it about 5 - 10 minutes
later everything is fine.

Any thoughts?



Rick Farley March 2nd 05 08:06 PM

What is TSB?

"twaldron" > wrote in message
. com...
> Loose connector behind the dash. It is a common prob. and there is a TSB
> out on it.
>
> Rick Farley wrote:
>
>> I live in the Sierras and over the past winter I have had a problem with
>> my instrument panel losing power when I have driven in the cold and snow
>> and have had my heater on, not knowing if the heater is part of the
>> problem. I have a 99 TJ Sahara and the first indication I get is that my
>> airbag light comes on then I lose speedometer and tachometer, then
>> finally the rest of the gauges. If I turn the vehicle off and restart it
>> about 5 - 10 minutes later everything is fine.
>>
>> Any thoughts?

>
> --
> __________________________________________________ _________
> tw
>
> 71 Bill Stroppe Baja Bronco
> 03 TJ Rubicon - Rubicon Express 4.5"
> 01 XJ Sport
>
> There is a very fine line between "hobby" and "mental illness."
> -- Dave Barry
>
> Pronunciation: 'jEp
> Function: noun
> Date: 1940
>
> Etymology: from g. p. (G= 'Government' P= '80 inch wheelbase')
> A small general-purpose motor vehicle with 80-inch wheelbase,
> 1/4-ton capacity, and four-wheel drive used by the U.S. army in
> World War II.
>
> (Please remove the OBVIOUS to reply by email)
> __________________________________________________ _________




Chuck Bremer March 2nd 05 08:08 PM

TSB= technical service bulletin. it's basically a procedure to fix a known
common problem, which is distributed to dealerships and mechanics who
subscribe to services such as AllData.


"Rick Farley" > wrote in message
...
> What is TSB?
>
> "twaldron" > wrote in message
> . com...
> > Loose connector behind the dash. It is a common prob. and there is a TSB
> > out on it.
> >
> > Rick Farley wrote:
> >
> >> I live in the Sierras and over the past winter I have had a problem

with
> >> my instrument panel losing power when I have driven in the cold and

snow
> >> and have had my heater on, not knowing if the heater is part of the
> >> problem. I have a 99 TJ Sahara and the first indication I get is that

my
> >> airbag light comes on then I lose speedometer and tachometer, then
> >> finally the rest of the gauges. If I turn the vehicle off and restart

it
> >> about 5 - 10 minutes later everything is fine.
> >>
> >> Any thoughts?

> >
> > --
> > __________________________________________________ _________
> > tw
> >
> > 71 Bill Stroppe Baja Bronco
> > 03 TJ Rubicon - Rubicon Express 4.5"
> > 01 XJ Sport
> >
> > There is a very fine line between "hobby" and "mental illness."
> > -- Dave Barry
> >
> > Pronunciation: 'jEp
> > Function: noun
> > Date: 1940
> >
> > Etymology: from g. p. (G= 'Government' P= '80 inch wheelbase')
> > A small general-purpose motor vehicle with 80-inch wheelbase,
> > 1/4-ton capacity, and four-wheel drive used by the U.S. army in
> > World War II.
> >
> > (Please remove the OBVIOUS to reply by email)
> > __________________________________________________ _________

>
>




Mike Romain March 2nd 05 08:08 PM

Technical service bulletin. Basically they are a list of screw ups and
how to fix them so maybe they don't screw up right away again.

These are screw ups not safety related so they don't have to issue a
recall for them or do them free.

In your case they got the wrong sized plug on the wiring harness so the
dash pins fit it really loose. Very likely a metric to standard size
screw up in my mind. There is a replacement plug available or you can
pull your plug and take a small pair of pliers and give each pin a
little twist, This seems to make them fit tight enough for the short
term, time will tell for the long term.

There are also some really shaky grounds on the back of the dash on some
TJ's too.

This place has the TSB's and the recalls:

http://www-odi.nhtsa.dot.gov/cars/problems/tsb/

Mike
86/00 CJ7 Laredo, 33x9.5 BFG Muds, 'glass nose to tail in '00
88 Cherokee 235 BFG AT's

Rick Farley wrote:
>
> What is TSB?
>
> "twaldron" > wrote in message
> . com...
> > Loose connector behind the dash. It is a common prob. and there is a TSB
> > out on it.
> >
> > Rick Farley wrote:
> >
> >> I live in the Sierras and over the past winter I have had a problem with
> >> my instrument panel losing power when I have driven in the cold and snow
> >> and have had my heater on, not knowing if the heater is part of the
> >> problem. I have a 99 TJ Sahara and the first indication I get is that my
> >> airbag light comes on then I lose speedometer and tachometer, then
> >> finally the rest of the gauges. If I turn the vehicle off and restart it
> >> about 5 - 10 minutes later everything is fine.
> >>
> >> Any thoughts?

> >
> > --
> > __________________________________________________ _________
> > tw
> >
> > 71 Bill Stroppe Baja Bronco
> > 03 TJ Rubicon - Rubicon Express 4.5"
> > 01 XJ Sport
> >
> > There is a very fine line between "hobby" and "mental illness."
> > -- Dave Barry
> >
> > Pronunciation: 'jEp
> > Function: noun
> > Date: 1940
> >
> > Etymology: from g. p. (G= 'Government' P= '80 inch wheelbase')
> > A small general-purpose motor vehicle with 80-inch wheelbase,
> > 1/4-ton capacity, and four-wheel drive used by the U.S. army in
> > World War II.
> >
> > (Please remove the OBVIOUS to reply by email)
> > __________________________________________________ _________


L.W.(ßill) Hughes III March 2nd 05 08:37 PM

http://www.billhughes.com/mirror/guages.htm
God Bless America, ßill O|||||||O


Rick Farley wrote:
>
> I live in the Sierras and over the past winter I have had a problem with my
> instrument panel losing power when I have driven in the cold and snow and
> have had my heater on, not knowing if the heater is part of the problem. I
> have a 99 TJ Sahara and the first indication I get is that my airbag light
> comes on then I lose speedometer and tachometer, then finally the rest of
> the gauges. If I turn the vehicle off and restart it about 5 - 10 minutes
> later everything is fine.
>
> Any thoughts?


IsellJeeps March 2nd 05 10:41 PM

follow Bills link it is a 10 minute fix!!!


"Rick Farley" > wrote in message
...
> I live in the Sierras and over the past winter I have had a problem with

my
> instrument panel losing power when I have driven in the cold and snow and
> have had my heater on, not knowing if the heater is part of the problem.

I
> have a 99 TJ Sahara and the first indication I get is that my airbag light
> comes on then I lose speedometer and tachometer, then finally the rest of
> the gauges. If I turn the vehicle off and restart it about 5 - 10 minutes
> later everything is fine.
>
> Any thoughts?
>
>




Rick Farley March 3rd 05 12:55 AM

Thanks for the info.

"IsellJeeps" > wrote in message
om...
> follow Bills link it is a 10 minute fix!!!
>
>
> "Rick Farley" > wrote in message
> ...
>> I live in the Sierras and over the past winter I have had a problem with

> my
>> instrument panel losing power when I have driven in the cold and snow and
>> have had my heater on, not knowing if the heater is part of the problem.

> I
>> have a 99 TJ Sahara and the first indication I get is that my airbag
>> light
>> comes on then I lose speedometer and tachometer, then finally the rest of
>> the gauges. If I turn the vehicle off and restart it about 5 - 10
>> minutes
>> later everything is fine.
>>
>> Any thoughts?
>>
>>

>
>





All times are GMT +1. The time now is 03:26 PM.

Powered by vBulletin® Version 3.6.4
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.
AutoBanter.com